Product ID:GLOSS ALIPHATIC POLYURETHANE, COMP A
MSDS Date:12/01/1988
FSC:8010
NIIN:00-181-8277
Kit Part:Y
MSDS Number: BMPYY

RANDOLPH PRODUCTS CO

701 12TH STT
CARLSTADT, NJ 07072
US

Emergency Phone: 201-438-3700

Info Phone: 201-438-3700

Cage: 77672

RANDOLPH PRODUCTS CO

830 CARLSTADT, NJ 07072-0830 US

Telephone: 201-438-3700

Cage: 77672

POLYESTER RESIN

Fraction By Weight: 20 - 30%

BUTYL ACETATE (VAPOR PRESSURE 14 MM HG @ 20 C) (LEL 1.7)

CAS: 123-86-4

RTECS: AF7350000

Fraction By Weight: 5 - 15%

ACGIH TLV: 150 PPM / 710 MG/M3

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

METHYL ETHYL KETONE (SARA 313) (VAPOR PRESSURE 80 MM HG @

CAS: 78-93-3

RTECS: EL6475000

Fraction By Weight: 10 - 20%

ACGIH TLV: 200 PPM / 590 MG/M3

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

XYLENE (SARA 313) (VAPOR PRESSURE 25 MM HG @ 20 C) (LEL

CAS: 1330-20-7

RTECS: ZE2100000

Fraction By Weight: 5 - 15%

ACGIH TLV: 100 PPM / 435 MG/M3

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

PROPYLENE GLYCOL METHYL ETHER ACETATE (VAPOR PRESSURE 2.5

CAS: 108-65-6

RTECS: AI8925000

Fraction By Weight: 25 - 35%

ACGIH TLV: 100 PPM

PIGMENTS

Fraction By Weight: 10 - 20%

ACGIH TLV: 10 MG/M3

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:BURNS, INJURY (FIRE/EXPLOS). OVEREXPOS
(SOLVENT)--PERM BRAIN & NERV SYS DAMAGE. CONC/INHAL--HARM/FATAL.
INHAL: NASAL IRRIT, DIZZY, WEAK, FATIGUE, NAUSEA, HEADACHE,
UNCONSCIOUS, ASPHYXIATION. EYE: IRRI T, RED, TEAR, BLURRED VISION.
SKIN: TOXIC EFFECTS, MINOR IRRIT, DEFAT, DERMATITIS. INGEST: TOXIC,
GASTROINTEST IRRIT,
Effects of Overexposure:NAUSEA, VOMIT & DIARRHEA. IN SHORT TERM,
REPEATED INHAL EXPOS TO NEARLY SATURATED VAPOR (>4000 PPM), TEST
ANIMALS SHOW SLIGHT EFFECT ON KIDNEYS/KIDNEY FUNCTION. PROLONGED
CONTACT W/INTACT & ABRADED RA BBIT SKIN SHOWED NO IRRIT & POTENTIAL
TO PRODUCE SYS TOXIC VIA SKIN ABSORPT IS LOW. ASPIRATION INTO
LUNGS-HARM/FATAL.
Medical Cond Aggravated by Exposure:N/K 21FEB92

First Aid:INHAL: MOVE TO FRESH AIR. KEEP QUIET. ADMIN OXYGEN/ARTIF RESP
AS NEEDED. GET MED AID. PROMPT ACTION-ESSENTIAL. EYE: IMMED FLUSH
EYES W/CLEAN, LOW PRESS WATER 15 MIN. LIFT EYELIDS. GET MED ATTN.
SKIN: REMOVE CONTAM CLOTH. WASH W/SOAP & WATER. IF STICKY, USE
WATERLESS CLEANER FIRST. DISCARD CONTAM SHOES. INGEST: GIVE WARM
WATER (QT) . GET MED AID. DON'T INDUCE VOMIT (RISK OF ASPIRATION
INTO LUNGS).

Flash Point Method:TCC
Flash Point:20.0F,-6.7C
Lower Limits:1.2
Extinguishing Media:SAND, FOAM, CARBON DIOXIDE, CHEMICAL TYPES.
Fire Fighting Procedures:DON'T ENTER CONFIND W/OUT PROTECTION/FIGHT
FROM DIST/PROTECT. CLSD CNTNR MAY EXPLOD W/HEAT. USE WTR
W/CARE(FROTH). LIMIT EXPOS OF EQUIP. MAY NEED SPECIAL FOAM.
Unusual Fire/Explosion Hazard:VAPOR RELEASED WHEN HEATED ABOVE FLASH
PT. FLAMM/EXPLOSIVE. VAPOR HEAVIER THAN AIR; TRAVEL TO IGNIT
SOURCE, FLASHBACK. SPRAY/MIST MAY BE COMBUST BELOW FLASH PT.

Spill Release Procedures:EVAC NONESSENTIAL. REMOVE IGNITION SOURCES.
STOP LEAK. NOTIFY FIRE/WATER SUPPLY/POLLUTION CONTROL AUTHORITIES.
EQUIP W/ PROPER PROTECTION. COVER SPILL W/FOAM. RESTRICT WATER USE.
LRG: DIKE/ IMPOUND SP ILL. SMALL: USE ABSORBENT. SHOVEL INTO
SUITABLE
Neutralizing Agent:N/K DISPOSAL CONTAINERS. ON WATER, MAT'L IS
SOLUBLE, WILL FLOAT.

Handling and Storage Precautions:KEEP AWAY FROM HEAT, FLAME. KEEP AWAY
FROM CHILDREN. GROUND CONTAINERS & EQUIPMENT. EMPTY CONTAINERS ARE
HAZARDOUS. DO NOT CUT OR WELD.
Other Precautions:N/K ATTEMPT TO CONTAIN AND RECOVER RAPIDLY TO
PREVENT DISPERSION. MAY BE TOXIC TO AQUATIC LIFE.

Respiratory Protection:IF MATERIAL IS HANDLED AT ELEVATED TEMPERATURES
OR UNDER MIST-FORMING CONDITIONS, NIOSH/MSHA APPROVED
SELF-CONTAINED BREATHING APPARATUS OPERATED IN A POSITIVE PRESSURE
MODE SHOULD BE USED.
Ventilation:USE MAT'L WHEN GENERAL ROOM VENTILATION CONTROLS POTENTIAL
EXPOS BELOW ANY HARMFUL LEVEL BASED ON MEDICAL SURVEILLANCE.
Protective Gloves:PROTECTIVE GLOVES.
Eye Protection:CHEM SPLASH GOGGLES, FACE MASK.
Other Protective Equipment:PROTECTIVE APRON AND FACE PROTECTION SHOULD
BE WORN. CONTACT LENSES SHOULD NO BE WORN. EQUIP-CLEANED AFTER EACH
USE.
Work Hygienic Practices:GOOD PERSONAL HYGIENE. WASH HANDS BEFORE EAT,
DRINK, SMOKE OR USING TOILET. TAKE SHOWER AFTER WORK USING
SOAP/WATER.
Supplemental Safety and Health

HCC:F2
Boiling Pt:B.P. Text:150 TO 302F
Vapor Density:> AIR
Evaporation Rate & Reference:SLOWER THAN ETHER.
Percent Volatiles by Volume:75

Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDANTS
Stability Condition to Avoid:FLAME OR HIGH HEAT NOTIFY AUTHORITIES IF
LIQUID ENTERS SEWERS OR PUBLIC WATERS.
Hazardous Decomposition Products:CARBON MONOXIDE MAY BE FORMED WHEN
BURNED.
Conditions to Avoid Polymerization:FLAME OR HIGH HEAT.

Waste Disposal Methods:CONTAM SOLIDS--LANDFILLED ONLY AT PROPERLY
PERMITTED DISPOSAL SITES. CARE IS NECESSARY TO AVOID
OVERLOAD/BIOMASS POISONING. ASSURE BIOPLANT EFFLUENT COMPLIANT
W/APPLIC WATER POLLUTION CONTROL REGS. RE COMM: CONTAM
MAT'L--REGARDED AS HAZARDOUS WASTE.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.